中科聚峰矿井车设备

  • 服务热线:

    15065707252

当前位置:首页 > 新闻中心 > 常见问题 >

新闻中心

服务热线电话

15065707252

隧道装载机轮胎会出现的故障?

来源:http://www.kuangjingjixie.com/ 发布时间:2022-08-22 浏览次数:200

内容详情:
隧道装载机轮胎会出现的故障?
What is the fault of tunnel loader tire?
隧道装载机在使用过程中会出现紧急状况,所以在出现状况时要先熄火,避免发生意外,尤其是轮胎不定时会出现各种状况,下面简单了解下装载机轮胎的情况吧。
Emergency situations may occur during the use of the tunnel loader. Therefore, in case of emergency, the engine should be shut down to avoid accidents. In particular, various conditions may occur when the tires are irregular. Let's briefly understand the situation of the loader tires.
我们在使用隧道装载机的过程当中,一旦发现轮胎气压、轮胎温度过高,应该要将车停在阴凉处降温以后再继续行驶,但不应该采用放气的方式降低轮胎的气压,或着用冷水浇发热的轮胎,避免在隧道装载机的工作过程中发生意外。
In the process of using the tunnel loader, once we find that the tire pressure and tire temperature are too high, we should park the vehicle in a cool place to cool down before continuing to drive. However, we should not reduce the tire pressure by deflating or pour hot tires with cold water to avoid accidents during the operation of the tunnel loader.
在夏季温度过高的时候,因为隧道装载机的轮胎层数多为14层左右,和大型的轮胎相比传热较快,很容易发生轮胎过热,使内压增高,促使轮胎的橡胶物理性能下降,以致引起爆胎。
When the temperature is too high in summer, because the number of tire layers of the tunnel loader is about 14, the heat transfer is faster than that of large tires, so it is easy to overheat the tire, increase the internal pressure, and promote the physical performance of the tire to decrease, resulting in tire burst.
装载机发动机的故障原因
Fault causes of loader engine
装载机发动机是一个非常重要的部件,在日常的使用中,难免会出现一些小的状况,为了方便大家更好的使用装载机,下面和大家讲解一下关于装载机发动机发生故障的原因:
The loader engine is a very important component. In daily use, it is inevitable that some small conditions will occur. In order to facilitate the better use of the loader, I will explain the reasons for the failure of the loader engine:
1、增压器损坏:增压器是影响装载机发动机动力的关键部件。如果增压器烧损,会造成转速下降、进气压力下降,显然发动机动力也会下降。
1. Supercharger damage: supercharger is a key component that affects the engine power of loader. If the supercharger is burnt out, it will cause the rotation speed to drop and the intake pressure to drop. Obviously, the engine power will also drop.
2、供气不足:增压柴油机靠排气压力吹动涡轮,从而带动泵轮高速旋转,而进气管道输送压缩空气,以保证发动机输出较大的功率。
2. Insufficient air supply: the supercharged diesel engine blows the turbine by the exhaust pressure to drive the pump wheel to rotate at high speed, while the intake pipe conveys compressed air to ensure that the engine outputs large power.
3、喷油正时不准确:如果喷油提前角过大,装载机的发动机会冒黑烟;如果喷油提前角过小,发动机会冒白烟。不管是冒黑烟还是冒白烟,都会引起发动机动力下降。
3. Inaccurate injection timing: if the injection advance angle is too large, the engine of the loader will emit black smoke; If the injection advance angle is too small, the engine will emit white smoke. Whether it is black smoke or white smoke, it will cause the engine power to drop.
4、供油不足供油不足:一方面是由于燃油泵的低压油路漏气,在小负荷情况下油量够用。另一方面是由于长期不保养,柴油滤清器被脏物堵塞,供油阻力增加使供油不畅,在小负荷小油量的情况下供油够用,但在大负荷大油量的情况下供油不足,造成发动机动力下降
4. Insufficient oil supply insufficient oil supply: on the one hand, the low-pressure oil passage of the fuel pump leaks, and the oil quantity is sufficient under small load. On the other hand, due to long-term maintenance, the diesel filter is blocked by dirt, and the oil supply resistance increases, which makes the oil supply not smooth. Under the condition of small load and small oil volume, the oil supply is sufficient, but under the condition of large load and large oil volume, the oil supply is insufficient, causing the engine power to drop
以上就是为大家介绍的有关隧道装载机的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以专业的态度,为您提供服务http://www.kuangjingjixie.com
The above is the detailed introduction of the tunnel loader for you. I hope it will help you. If you have any questions, please contact us. We will provide you with services in a professional manner http://www.kuangjingjixie.com